Analysis of bush pear and its oil

  • Ms Word Format
  • 75 Pages
  • ₦3000
  • 1-5 Chapters



The research project studies the analysis of pear and its oil. The mesocarp from edible African pear “DacryodesEdulis” were evaluated for their oil yield. The pulp from this pear were oven dried at 100oC-105oC to a moisture content level of 29%.The mesocarp was subjected to proximate analysis to determine the percentage of the moisture, ash, fat, crude fibre, crude protein and carbohydrate content which resulted to the values of 29%, 2%, 19.6%, 25.5%, 11.9%, and 12% respectively. Then the dried sample was pulverized by using hammer mill and the oil was extracted by solvent extraction using n-hexane. The oil extracted were analyzed for the chemical properties i.e. (Acid value, saponification value, peroxide value, iodine value) etc. the  values obtained are respectively

8.41gm/KOH/gm, 185.1gm/KOH/gm, 2.8gm/KOH/gm  3.96gm/iodine/gm and Physical properties i.e. (Refractive index, Ph value, specific gravity) which the values obtained are 1.469brix, 5.7 and 0.92. and the The percentage oil yield content is  51.57%. This physio-chemical characteristic and fatty acid composition of this oil show that they have industrial potentials.


Chapter one

1.0  Introduction

1.1     Historical background of the study

1.2     Aims and objectives

1.3     Statement of the problem

1.4     Significance/economic importance of the study

1.5           Scope and limitation of the study

chapter two

2.0     Literature review

2.1     Introduction

2.2  Extraction

2.2.1 Mechanical/physical method of extraction

2.2.2 Chemical/solvent method

2.2.3 Basic principles of solvent extraction

2.2.4 Choice of solvent/solvent properties

2.2.5 Applications of solvent extraction

2.2.6 Methods of leaching operations

2.2.7 Solvent extraction theory

2.2.8 Factors affecting the rate of extraction

2.2.9 Properties of solvent

2.3.0  Extractors

2.3.1 Distillation as a separation technique

2.3.2 Classification of oils

2.3.3    Properties of oil

2.4  African Pear

2.4.1 Features of the African pear

2.4.2 Taxonomy of the African pear plant

2.4.3 Characteristic and composition of the African

2.5.0 Oil from African pear

2.5.1 Uses of African pear

2.5.2 Economic values of African pear

Chapter Three

3.0 Characterisation of dacryodesedulis

3.1 Experiment Procedures

3.1.1 Material/Equipment

3.1.2 Reagents

3.2 Pre-treatment processes

3.3 Extraction of the oil

3.4 Characterisation of the oil.

3.4.1 To Determine the percentage yield of the oil

3.5 Proximate analysis of dacryodesedulis

3.5.1 To determine the moisture contents of the sample

3.5.2 To Determine the ash content of the sample

3.5.3 To determine the fat content of the sample (lipid – fat & oil)

3.5.4 To Determine the crude fibre of the sample

3.5.5 To Determine carbohydrate content

3.6     Chemical analysis of the oil

3.6.1 Determination of acid value of the african pear oil

3.6.2 Determination of the iodine value of african pear oil

3.6.3:   Determination of the peroxide value of african pear oil

3.6.4 Determination of saponification value of the oil

3.7     Physical analysis of the oil

3.7.1 To Determine the refractive index of the oil

3.7.2 To Determinethe specific gravity of African pear oil

3.7.3 Determination of the ph value of African pear oil

Chapter Four

4.0     Experimental results and discussion

4.1     Tables and results

4.2     Discussion

Chapter Five

5.0   Conclusion and recommendation

5.1   Conclusion

5.2   Recommendation





 In the major world, one major source of protein and vegetable oil is from oil seeds /fruits (Williams M. A. 1996).  Oil constitutes a well defined class of naturally occurring substance. It is greasy, being soluble in organic solvents but insoluble in polar solvents such as water. Oil is a liquid at room temperature. Commercially, oil as well as fats is sourced from certain plant groups mostly seeds and nuts and some parts of animal within which they occur in relatively large quantity in an easily available form (McGraw-Hill, 1997).  The existence of oil in certain plants has been known for century of years (Ogbu 2005).Oil can be grouped into edible and non-edible oil depending on the amount of unsaponified matters and impurities contained therein. Edible oil extracted from African pear, bread fruits, cashew nut, peanut etc. are examples of vegetable oil which are naturally occurring esters of higher fatty acids and glycerol, and are predominantly triglycerides with traces of mono and diglycerides, sterples, antioxidants, vitamins, saturated and unsaturated free fatty acids and other minor constituents. They are widely distributed in nature and were first consumed as food. Later, oils were discovered to be used as renewable raw materials for variety of non-food production. For instance; soaps, creams, disinfectants, paints, enamels, inks etc.

Due to the oil boom in the early 70‟s, agriculture was abandoned for petroleum and its product, but recently, things are taking a new turn in Nigeria over dependence on petroleum for virtually everything has not really helped matters. The economic situation in the country is bad and the general standard of living is getting poorer with each passing day, Hence, the need for a restructure of the economic system with an agricultural bias.

Most agriculture products such as these oils extracted from local seeds and nut, if properly monitored and harvested can be very useful for us down here and even exported for foreign exchange, hence the need for this project which deals on the extraction and analysis of African pear oil.

Extraction of oil from various vegetable resources is of ancient origin. In fact, the natives from different tropical regions of the globe have long been extracting oil from numerous oil-bearing plants. Humans, since the ancient times have known how to extract fats and oil from their natural resources. Historically, oils had been extracted by wrapping nuts in clothes and then using devices operated by stones and levers to exert pressure on them. But now, an improved form of mechanical device, which allowed considerably more pressure to be exerted, is now in use in form of hydraulic operated ram. This type of press is developed into a motorized hydraulic pump system that pressed the nut bag and then released a pressed cake. The next improvement in extracting oil is the screw press or expeller which is been driven by electric motor.Because most press or expeller processes leads to over-heating of the meal and leave too- much of the high value oil in cakes, better methods of extracting the oil with solvent was developed. Bush pear was processed by solvent methods alone in this project. This process can be accomplished by a variety of ways but as might be expected, its efficiency depends to a great extent on attaining intimate contact between the liquid solvent and the solid containing the solute. The type of solvent available for this process include nhexane, petroleum ether, benzene, n-heptanes, acetone etc.


The generic name “Dacryodes” was derived from the Greek word “Dakruon” meaning [tear] referring to resin droplets on the bank surface of its member while “Edulis” means edible emphasizing the importance of nutrients fruits in the plants cultivation .The plant belongs to the family Burseraceae whose members are characterized by an ovary of 2to 5 cells, prominent as inducts in the bark, wood, and intrasteminal disk (Chunduff, 1984).  The genus Dacryodes consist of about 10 species (Verheji, 2002). However (Rehn, 1984) indicated 80 species to encompass sub species of varieties, form and cultivars. Two varieties are recognized; Var-parvicarpa and Var-edulis whose conical fruit is smaller with the pulp. Var-edulis exhibit verticulate or sub-verticulate branching while the branching is slender and opposite or bifurcate in var-parvicarpa (Okafor 1983).

Dacryodesedulis is an indigenous fruit in the Gulf of  Guinea and central African countries(Troupin, 1950), but due to the popularity of the nutritious fruit for consumption, the plant is widely cultivated, extend its area of distribution to Sierra-Leone, Uganda, Angola, Zimbabwe and Nigeria. It rarely grows wild, thus the natural area of distribution is obscure (verheji,2002). Lam gave four synonyms viz to the Dacryodesedulis :CarnaruimedulieHook.f,

CarnaruimsaphuEngl, Pachylobusedulis (G.don) Hook. F. and

PachylobussaphuEngl (Burkill ,1985,National research council,1996).

However, these synonyms have long been considered as the most unambiguous synonyms (Boutelje,1980).The common names are in English,  African pear,

African pear tree, Bush butter, Bush butter tree, Bush fruit tree, Eben tree, Native pear (Kapseu and Tchiegang, 1996)  and in French, Safoutier (Burkill, 1985). The oil of fruits of DacryodesEdulis is a rich source of amino acids and triglycerides. The fatty acid composition of fruit pulp oil of two cultivars of bush pear [cultivar1 and cultivar2] grown in Nigeria were determined. The oil is found in the pulp which is made up of 48% of oil and a plantation can produce 7.8 tons of oil per hectare. It is also rich in vitamins and a rich source of amino acids triglycerides ( al 1976).

Bush pear oil is one of the most important rated versatile vegetable oil. This is due to its uses in various spheres of life, most especially as a very healthy food ingredient.


This project is aimed at the analysis of bush pear and its oil.The main objective of this study is to carry out proximate analysis and physio-chemical properties of African pear oil extracted by solvent methods. This physio-chemical properties determined are specific gravity, refractive index, ph value, boiling point, acid value, iodine value, peroxide value, and saponification value. To achieve the objectives of this project, it is important to:-

  1. Select the best suited solvent for optimum yield.
  2. Characterize the extracted oil for compositions and properties.
  3. Test the suitability of the oil.


This research work involves the analysis of African pear and its oil though the food crop African pear potential  is rated one of the highest oil producing fruit crop yet it begs the question of its potential.

Furthermore, this project will answer the following questions;

  1. Solvent extraction by solvent method
  2. What is the optimum yield of the particle size using n- hexane?
  3. Is there significant difference in the characterization of the extracted oil as compared to theoretical value in terms of;
  • Chemical properties (Acid value, iodine value, saponification value and peroxide value).
  • Physical properties (specific gravity, density, viscosity, refractive index).
  • Chemical composition (protein crude, fibre, carbohydrate and moisture.


Characterizing the potentials of African pear/African pear oil for many purposes has several implications. Communities in the West African countries are significantly dependent on financial gain from agrarian enterprise.

It is hope that from the project, optimum extraction parameters which are quality of the oil would be established, the result would add to the data bank that could help potential industrialist who intends to go into vegetable table oil production from African pear. A crop that experiences a post harvest loss in excess of 40% in areas where malnutrition is prevalent is a problem for potentials to reclaim the lost percentage of either food or other purposes is advantageous for producers and consumers alike.

Furthermore, the development of crops with indigenous appeal can strengthen the agricultural and energy sectors of struggling economics, identifying the oils fuels quantities, whether favorable or not, will help to inform future crop and industry development.


In this project work, we intend to analyze and extract completely African pear and its oil. Many research work has been done in giving a detailed composition found in African pear. But this research account on the optimum route to:

  1. Extraction of vegetable oil from bush pear. ii) Separation of pure oil from the solvent. iii) Characterization of the African pear.
  2.  Characterization of the oil extracted.

Due to the low yield of the above method (mechanical method) of extraction, soxhlet and cold method of extraction are used i.e. solvent extraction.

Leave a Reply

Your email address will not be published. Required fields are marked *

You May Also Like